Kohler Command Pro CH980 User Manual

Browse online or download User Manual for For the car Kohler Command Pro CH980. Kohler Command Pro CH980 User Manual

  • Download
  • Add to my manuals
  • Print

Summary of Contents

Page 1 - COMMAND PRO

1OWNER'S MANUALHORIZONTAL CRANKSHAFTCOMMAND PROCH940-CH1000

Page 2 - Proposition 65 Warning

10Figure 15. Optional Remote Mounted Oil Filter.Replace the oil filter as follows:1. Before removing the oil filter, clean the areaaround the oil filt

Page 3 - WARNING WARNING

11To access and service the oil cooler, remove the topmounting screw and loosen the two side screws, thenlift off the No. 2 side cylinder shroud. If r

Page 4 - Oil Recommendations

12Figure 21. Removing Elements.3. After the paper element is removed, check thecondition of the inner element. It should bereplaced whenever it appear

Page 5 - Model Designation

13Ignition SystemAn electronic Capacitive Discharge (CD) ignitionsystem is used. Other than periodically checking/replacing the spark plugs, no mainte

Page 6 - Pre-Start Checklist

14Figure 26. Keihin Two-Barrel Carburetor.NOTE: Carburetor adjustments should be made onlyafter the engine has warmed up.NOTE: To ensure correct engin

Page 7 - Operating

15Adjust CarburetorLow Idle Speed (RPM) and Governed IdleAdjustment1. Low Idle Speed (RPM) Setting: Place the throttlecontrol into the idle or slow po

Page 8 - Maintenance Instructions

16TroubleshootingWhen troubles occur, be sure to check the simple causes which, at first, may seem too obvious to be considered.For example, a startin

Page 9

17SpecificationsModel: ... CH940 ... CH960 ... CH980 .

Page 10

18KOHLER CO.FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMSLIMITED WARRANTYSMALL OFF-ROAD AND CLASS 1 LSI ENGINESThe U.S. Environmental Protection Age

Page 11 - Air Cleaners

19Listed below are the parts covered by the Federal and California Emission Control Systems Warranty. Some parts listed belowmay require scheduled mai

Page 12

2Safety PrecautionsTo ensure safe operations please read the following statements and understand their meaning.Also refer to your equipment owner&apos

Page 13 - Check Spark Plugs

ENGINE DIVISION, KOHLER CO., KOHLER, WISCONSIN 53044FOR SALES AND SERVICE INFORMATIONIN U.S. AND CANADA, CALL 1-800-544-2444LITHO IN U.S.A.FORM NO.: 6

Page 14 - Battery Charging

3Safety Precautions (Cont.)Lethal Exhaust Gases!Engine exhaust gases contain poisonouscarbon monoxide. Carbon monoxide isodorless, colorless, and can

Page 15

4Figure 1. Typical Command PRO Horizontal Shaft Engine.Oil RecommendationsUsing the proper type and weight of oil in thecrankcase is extremely importa

Page 16 - Parts Ordering

5Fuel RecommendationsWARNING: Explosive Fuel!Gasoline is extremely flammable and its vapors can explode ifignited. Store gasoline only in approved con

Page 17 - Specifications

6Operating InstructionsAlso read the operating instructions of the equipment this engine powers.Figure 6. Throttle and Choke Control Linkage inInner P

Page 18 - LIMITED WARRANTY

7Figure 8. Optional Control Panel with EngineMounted Controls.2. Start the engine by activating the key switch.Release the switch as soon as the engin

Page 19

8Check Oil LevelThe importance of checking and maintaining theproper oil level in the crankcase cannot beoveremphasized. Check oil BEFORE EACH USE asf

Page 20 - KohlerEngines.com

9Figure 9. Dipstick and Oil Fill.4. Remove the dipstick and check the oil level. Theoil level should be up to, but not over, the F markon the dipstick

Comments to this Manuals

No comments