1OWNER'S MANUALHORIZONTAL CRANKSHAFTCOMMAND PROCH940-CH1000
10Figure 15. Optional Remote Mounted Oil Filter.Replace the oil filter as follows:1. Before removing the oil filter, clean the areaaround the oil filt
11To access and service the oil cooler, remove the topmounting screw and loosen the two side screws, thenlift off the No. 2 side cylinder shroud. If r
12Figure 21. Removing Elements.3. After the paper element is removed, check thecondition of the inner element. It should bereplaced whenever it appear
13Ignition SystemAn electronic Capacitive Discharge (CD) ignitionsystem is used. Other than periodically checking/replacing the spark plugs, no mainte
14Figure 26. Keihin Two-Barrel Carburetor.NOTE: Carburetor adjustments should be made onlyafter the engine has warmed up.NOTE: To ensure correct engin
15Adjust CarburetorLow Idle Speed (RPM) and Governed IdleAdjustment1. Low Idle Speed (RPM) Setting: Place the throttlecontrol into the idle or slow po
16TroubleshootingWhen troubles occur, be sure to check the simple causes which, at first, may seem too obvious to be considered.For example, a startin
17SpecificationsModel: ... CH940 ... CH960 ... CH980 .
18KOHLER CO.FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMSLIMITED WARRANTYSMALL OFF-ROAD AND CLASS 1 LSI ENGINESThe U.S. Environmental Protection Age
19Listed below are the parts covered by the Federal and California Emission Control Systems Warranty. Some parts listed belowmay require scheduled mai
2Safety PrecautionsTo ensure safe operations please read the following statements and understand their meaning.Also refer to your equipment owner&apos
ENGINE DIVISION, KOHLER CO., KOHLER, WISCONSIN 53044FOR SALES AND SERVICE INFORMATIONIN U.S. AND CANADA, CALL 1-800-544-2444LITHO IN U.S.A.FORM NO.: 6
3Safety Precautions (Cont.)Lethal Exhaust Gases!Engine exhaust gases contain poisonouscarbon monoxide. Carbon monoxide isodorless, colorless, and can
4Figure 1. Typical Command PRO Horizontal Shaft Engine.Oil RecommendationsUsing the proper type and weight of oil in thecrankcase is extremely importa
5Fuel RecommendationsWARNING: Explosive Fuel!Gasoline is extremely flammable and its vapors can explode ifignited. Store gasoline only in approved con
6Operating InstructionsAlso read the operating instructions of the equipment this engine powers.Figure 6. Throttle and Choke Control Linkage inInner P
7Figure 8. Optional Control Panel with EngineMounted Controls.2. Start the engine by activating the key switch.Release the switch as soon as the engin
8Check Oil LevelThe importance of checking and maintaining theproper oil level in the crankcase cannot beoveremphasized. Check oil BEFORE EACH USE asf
9Figure 9. Dipstick and Oil Fill.4. Remove the dipstick and check the oil level. Theoil level should be up to, but not over, the F markon the dipstick
Comments to this Manuals