OWNER'S MANUALVERTICAL CRANKSHAFTCOMMAND PROCV940-CV1000
10Figure 15. Optional Remote Mounted Oil Filter.Replace the oil filter as follows:1. Before removing the oil filter, clean the areaaround the oil filt
11Inspect and clean the oil cooler every 150 hours ofoperation (more frequently under severe conditions).Oil cooler must be kept free of debris.To acc
12Figure 22. Ejector Area.6. Install the new inner element, Kohler Part No.25 083 04-S followed by the paper element,Kohler Part No. 25 083 01-S. Slid
134. Reinstall the spark plug into the cylinder head.Torque the spark plug to 24.4-29.8 N·m(18-22 ft. lb.).Battery ChargingWARNING: Explosive Gas!Batt
14• Make sure fuel is reaching the carburetor. Thisincludes checking the fuel lines and fuel pump forrestrictions or faulty components, replace asnece
15StorageIf the engine will be out of service 30 days or more, usethe following storage procedure:1. Clean the exterior surfaces of the engine. Avoids
16SpecificationsModel: ... CV940 ... CV960 ... CV980 .
17KOHLER CO.FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMSLIMITED WARRANTYSMALL OFF-ROAD AND CLASS 1 LSI ENGINESThe U.S. Environmental Protection Age
18Listed below are the parts covered by the Federal and California Emission Control Systems Warranty. Some parts listed below mayrequire scheduled mai
2Safety PrecautionsTo ensure safe operations please read the following statements and understand their meaning.Also refer to your equipment owner&apos
FORM NO.: 62 590 02-AENGINE DIVISION, KOHLER CO., KOHLER, WISCONSIN 53044FOR SALES AND SERVICE INFORMATIONIN U.S. AND CANADA, CALL 1-800-544-2444LITH
3Safety Precautions (Cont.)Lethal Exhaust Gases!Engine exhaust gases contain poisonouscarbon monoxide. Carbon monoxide isodorless, colorless, and can
4Figure 2. Viscosity Grades Table.NOTE: Using other than service class SJ or higher oilor extending oil change intervals longer thanrecommended can ca
5Fuel RecommendationsWARNING: Explosive Fuel!Gasoline is extremely flammable and its vapors can explode ifignited. Store gasoline only in approved con
6Pre-Start Checklist• Check oil level. Add oil if low. Do not overfill.• Check fuel level. Add fuel if low.• Check cooling air intake areas and extern
7Figure 8. Choke Control Lever.2. Start the engine by activating the key switch.Release the switch as soon as the engine starts.NOTE: Do not crank the
8Check Oil LevelThe importance of checking and maintaining theproper oil level in the crankcase cannot beoveremphasized. Check oil BEFORE EACH USE asf
9Oil Fill Cap/DipstickFigure 9. Oil Fill Cap/Dipstick.4. Remove the oil fill cap/dipstick and check oillevel. The level should be between the “F” and“
Comments to this Manuals