Kohler Courage SV720 User Manual Page 7
- Page / 20
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
7
Maintenance Instructions
Maintenance, repair, or replacement of the emission control devices and systems, which are being done at the
customers expense, may be performed by any non-road engine repair establishment or individual. Warranty
repairs must be performed by an authorized Kohler service outlet.
WARNING: Accidental Starts!
Disabling engine. Accidental starting can cause severe injury or death. Before working on the engine or
equipment, disable the engine as follows: 1) Disconnect the spark plug lead(s). 2) Disconnect negative (-) baery
cable from baery.
Maintenance Schedule
These required maintenance procedures should be performed at the frequency stated in the table. They should
also be included as part of any seasonal tune-up.
WARNING: Hot Parts!
Engine components can get extremely hot from operation.
To prevent severe burns, do not touch these areas while
the engine is running, or immediately aer it is turned
off. Never operate the engine with heat shields or guards
removed.
Engine Speed
NOTE: Do not tamper with the governor seing
to increase the maximum engine speed.
Overspeed is hazardous and will void the
engine warranty. The maximum allowable
high idle speed for these engines is 3675 RPM,
no load.
Refer to the operating instructions of the equipment
this engine powers. Because of equipment design or
application, there may be more stringent restrictions
regarding the angle of operation.
NOTE: Do not operate this engine continuously
at angles exceeding 25° in any direction.
Engine damage could result from insufficient
lubrication.
Cooling
NOTE: If debris builds up on the grass screen or other
cooling areas, stop the engine immediately
and clean. Operating the engine with blocked
or dirty air intake and cooling areas can cause
extensive damage due to overheating. See
Clean Air Intake/Cooling Area.
Check Oil Level
The importance of checking and maintaining
the proper oil level in the crankcase cannot be
overemphasized. Check oil BEFORE EACH USE as
follows:
1
Perform these maintenance procedures more frequently under extremely dusty, dirty conditions.
2
Have a Kohler Engine Service Dealer perform these services.
1. Make sure the engine is stopped, level, and is cool
so the oil has had time to drain into the sump.
2. Clean the area around and the underside of the
oil fill cap/dipstick before removing it. This will
help keep dirt, debris, and other foreign maer
out of the engine.
Frequency Maintenance Required
• Fill fuel tank.
• Check oil level.
• Check air cleaner for dirty
1
, loose, or damaged parts.
• Check air intake and cooling areas, clean as necessary
1
.
• Service precleaner element
1
.
Daily Or Before
Starting Engine
Every 25 Hours
• Replace air cleaner element and precleaner¹.
• Change oil and oil filter (more frequently under severe conditions).
• Remove cooling shrouds and clean cooling areas¹.
• Replace fuel filter.
• Check spark plug condition and gap.
Every 50 Hours
• Check air cleaner element, clean or replace as necessary¹.
Annually or
Every 100 Hours
• Have valve lash checked/adjusted
2
.
Every 200 Hours
Every 500 Hours
• Have bendix starter drive serviced
2
.
• Have solenoid shi starter disassembled and cleaned
2
.
- OWNER'S MANUAL 1
- COURAGE SV710-740 1
- COURAGE PRO SV810-840 1
- Safety Precautions 2
- California 2
- Proposition 65 Warning 2
- Safety Precautions (Cont.) 3
- Oil Recommendations 4
- Fuel Recommendations 4
- General Recommendations 5
- Engine Identification Numbers 5
- Maintenance Instructions 7
- Change Oil and Oil Filter 8
- Troubleshooting 13
- SV710-740 Specifications 14
- Parts Ordering 14
- Major Repair 14
- Model Designation 14
- SV810-840 Specifications 16
- Courage PRO 16
- COURAGE PRO 17
- Continued on next page 18
- KohlerEngines.com 20
Related products and manuals for For the car Kohler Courage SV720
For the car Kohler Aegis LH640 User Manual
(20 pages)
(20 pages)
For the car Kohler KD477-2 User Manual
(120 pages)
(120 pages)
For the car Kohler CH18-26 User Manual
(19 pages)
(19 pages)
For the car Kohler Aegis LV675 User Manual
(20 pages)
(20 pages)
For the car Kohler KDW1003 User Manual
(152 pages)
(152 pages)
For the car Kohler Courage SV600 User Manual
(16 pages)
(16 pages)
For the car Kohler KT19 User Manual
(17 pages)
(17 pages)
For the car Kohler Command CH620 User Manual
(20 pages)
(20 pages)
For the car Kohler Command CV730 User Manual
(217 pages)
(217 pages)
For the car Kohler Command CV740 User Manual
(24 pages)
(24 pages)
Dynamix DW-01 manuals
Owner’s manuals and user’s guides for Gateways/controllers Dynamix DW-01.
We providing 1 pdf manuals Dynamix DW-01 for download free by document types: User Manual
Comments to this Manuals