Kohler COMMAND PRO CS Series User Manual

COMMAND PRO CS SERIES 4-12.75 HPHORIZONTAL CRANKSHAFTOWNER'S MANUAL

10Reduction Systems2:1 Reduction SystemsAll 2:1 reduction systems are lubricated by thecrankcase oil of the engine through special openings inthe clos

11On Heavy Duty Air Cleaner Systems:Remove and clean the lower dirt/swirl chamber.Make sure the openings near the base ofchamber and in the air cleane

12Check Spark PlugAnnually or every 100 hours of operation, remove thespark plug, check condition, and reset the gap orreplace with new plug as necess

13Figure 15.Fuel Tank FilterA serviceable fuel tank filter is located under the fueltank cap, in the filler neck.Daily or as required clean filter of

14Idle FuelNeedleIdle SpeedScrewMuffler Screen and Spark Arrestor CS8.5,CS10,CS12CAUTION!The engine and muffler will be very hot after the enginehas b

15TroubleshootingWhen troubles occur, be sure to check the simple causes which, at first, may seem too obvious to be considered.For example, a startin

16StorageIf the engine will be out of service for two months ormore, use the following storage procedure:1. Clean the exterior surfaces of the engine.

17 LIMITED 2 YEAR COMMAND ENGINE WARRANTYKohler Co. warrants to the original consumer that each new COMMAND engine sold by Kohler Co. will be free fro

18KOHLER CO.FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMSLIMITED WARRANTYSMALL OFF-ROAD ENGINESThe U.S. Environmental Protection Agency (EPA), the C

19LIMITATIONSThis Emission Control Systems Warranty shall not cover any of the following:(a) repair or replacement required because of misuse or negle

2Safety PrecautionsTo ensure safe operations please read the following statements and understand their meaning.Also refer to your equipment owner&apos

FOR SALES AND SERVICE INFORMATIONIN U.S. AND CANADA, CALL1-800-544-2444www.kohlerengines.comENGINE DIVISION, KOHLER CO., KOHLER, WISCONSIN 53044FORM N

3Safety Precautions (Cont.)Accidental Starts can cause severeinjury or death.Disconnect and ground spark pluglead before servicing.WARNINGCarbon Monox

4Figure 1. Location of Controls and Service Points on CS Engines.Oil RecommendationsUsing the proper type and weight of oil in the crankcaseis extreme

5Engine Identification NumbersWhen ordering parts, or in any communication involvingan engine, always give the Model, Specification, andSerial Numbers

6Operating InstructionsAlso read the operating instructions of the equipment this engine powers.Pre-Start ChecklistNOTE: This engine has been shipped

7WARNING: Accidental Starts!Disabling engine. Accidental starting can causesevere injury or death. Before working on the engineor equipment, disable t

8Maintenance InstructionsMaintenance, repair, or replacement of the emission control devices and systems, which are being doneat the customers expense

9NOTE: If the engine stalls or does not start, turn theengine switch to ‘‘on’’ position and then pullthe recoil starter or attempt to start engine. If