Kohler Courage XT-6 User Manual download pdf (Page 10)

Maintenance Instructions

Frequency

Maintenance Required

After First 3-5 Hours of Operation

Change oil

Daily or Before Starting Engine

Fill fuel tank

Check oil level.

Check air intake and cooling areas; clean as necessary¹

Yearly or Every 25 Hours

Service or replace precleaner element (if equipped)¹

ȱȱȱȱȱęȱȱ¢ǰȱȱȱȱŵ

Yearly or Every 50 Hours

ȱȱęȱǻȱǼ

Change oil

Yearly or Every 100 hours

Replace spark plug and set gap

ȱȱȱęŵ

ȱȱȱę

Adjust valves

Clean combustion chamber

Figure 12. Maintenance Table.

¹Perform these maintenance procedures more frequently under extremely dusty, dirty conditions.

These procedures should be performed by a Kohler Authorized Service Center.

Oil Level Check

The importance of checking and maintaining

the proper oil level in the crankcase cannot be

overemphasized.

Check oil BEFORE EACH USE as follows:

1. Make sure the engine is stopped, level, and cool

so the oil has had time to drain into the sump.

Řǯȱ ȱȱȱȱȱȱęȱȦȱȱ

keep dirt and grass clippings out of the engine.

řǯȱ ȱȱȱȱȱęȱȦǲȱ

ȱěȱǯȱȱȱȱȱȱȱ

ȱȱȱȱęȱȱȱȱǯȱDO NOT

screw the cap into the tube. See Figure 13.

Oil Fill Cap/Dipstick

Figure 13. Oil Fill Cap/Dipstick.

Śǯȱ ȱȱȱȱȱȱǯȱȱ

should be up to, but not over F or FULL mark on

ǯȱȱȱŗŚǯ

Operating

Range

Full Mark

Low Mark

Figure 14. Oil Level Dipstick.

śǯȱ ȱȱȱȱǰȱȱȱȱ¢ȱȱȱȱȱ

the F or FULL mark on dipstick. Always check the

oil level with the dipstick before adding more.

Ŝǯȱ ȱȱęȱȦȱȱȱ¢ǯ

NOTE: To prevent extensive engine wear or damage,

always maintain proper oil level in crankcase.

Never operate engine with oil level below the

L or LOW mark, or over the F or FULL mark

on dipstick.

1 2 ... 5 6 7 8 9 10 11 12 13 14 15 ... 18 19

Comments to this Manuals

No comments

Kohler Courage XT-6 User Manual Page 10

Comments to this Manuals