OWNER'S MANUALVERTICAL CRANKSHAFTCOURAGE SV710-740COURAGE PRO SV810-840
10Service Paper ElementCheck the paper element every 50 hours of operation, (more oen under extremely dusty or dirty conditions). Clean or replace th
11 NOTE: Operating the engine with a blocked grass screen, dirty or plugged cooling fins, and/or cooling shrouds removed, will cause engine damage due
12Low Idle Mixture ScrewIdle Speed (RPM) Adjustment ScrewFuel SolenoidIf, aer checking the items listed above, the engine is hard to start, runs roug
13The system requires an additional procedure for seing the idle speed. If speed adjustments are required proceed as follows. 1. Make any necessary
14Courage® SV710-740 SpecificationsModel: ...SV710 ...
15COURAGE® SV710-740 ENGINE LIMITED WARRANTYKohler Co. warrants to the original retail consumer that each new COURAGE® engine sold by Kohler Co. will
16Courage PRO™ SV810-840 SpecificationsModel: ...SV810 ...
17COURAGE PROTM SV810-840 ENGINE LIMITED WARRANTYKohler Co. warrants to the original retail consumer that each new COURAGE PRO™ engine sold by Kohler
18Continued on next page.KOHLER CO.FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMSLIMITED WARRANTYSMALL OFF-ROAD ENGINESThe U.S. Environmental Protect
19 • Fuel lines, fuel line fiings and clamps (if equipped) • Air filter, fuel filter, and spark plugs (only • Spark advance module (if equipped)
2Safety PrecautionsElectrical Shock!Never touch electrical wires or components while the engine is running. They can be sources of electrical shock.CA
REVISED: 6/09LITHO IN U.S.A.FORM NO.: 32 590 01-BISSUED: 9/05ENGINE DIVISION, KOHLER CO., KOHLER, WISCONSIN 53044FOR SALES AND SERVICE INFORMATION IN
3Accidental Starts can cause severe injury or death.Disconnect and ground spark plug leads before servicing.WARNINGCarbon Monoxide can cause severe na
4Oil FilterAir Cleaner Access Door Handle Rectifier-RegulatorFuel PumpIdentification PlateOil RecommendationsUsing the proper type and weight of oil in
5General RecommendationsPurchase gasoline in small quantities and store in clean, approved containers. A container with a capacity of 2 gallons or les
6Operating InstructionsAlso read the operating instructions of the equipment this engine powers.Pre-Start Checklist • Check oil level. Add oil if lo
7Maintenance InstructionsMaintenance, repair, or replacement of the emission control devices and systems, which are being done at the customers expens
8 Figure 5. Dipstick Styles. Figure 8. Oil Drain Plug. 3. Remove the oil fill cap/dipstick; wipe oil off. For engines with a press-on style dipstick
9Change the oil and oil filter as follows. 1. The drain plug is located on the starter side of the oil pan. See Figure 8. Clean the area around the
Comments to this Manuals