Kohler 3.5CFZ User Manual Page 16
- Page / 81
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
TP-5695 12/93 Specifications 1-1
Section 1. Specifications
Introduction
The craft is equipped with a dependable 110 volt
(reconnectable to 110/220 volt), 50 Hz; or 120 volt
(reconnectable to 120/240 volt), 60 Hz single-phase
alternating current marine generator set. Service
requirements are minimal but are very important to the
safe and efficient operation of the generator set;
therefore, inspect associated parts often. It is
recommended that an authorized service
dealer/distributor perform required servicing to assure
the unit continues to meet U.S.C.G. requirements.
Please take a few moments to read this manual, then
carefullyfollow allservicerecommendations tokeepthe
set in top condition. Keep this manual aboard the craft
for future reference. See Figure 1-1 for identification
and location of components.
Specifications
General Specifications
3.5CFZ 5CFZ
Dimensions--L x W x H--in. (mm) 27.87 x 17.50 x 16.60
(708 x 445 x 422)
31.07 x 18.10 x 17.50
(789 x 460 x 445)
with Sound Shield 31.07 x 18.10 x 17.50
(789 x 460 x 445)
31.07 x 18.10 x 17.50
(789 x 460 x 445)
Weight--(wet), lbs. (kg) 208 (94) 231 (104)
with Sound Shield 231 (104) 231 (104)
Air Requirements--cfm (L/min.) 18 (510) 18 (510)
Fuel Consumption U.S. gal./hr. (L/hr.)
Load
25% 0.42 (1.59) 0.44 (1.67)
50% 0.50 (1.89) 0.54 (2.04)
75% 0.59 (2.23) 0.66 (2.50)
100% 0.68 ( 2.57) 0.80 (3.03)
4CZ 6.5CZ
Dimensions--L x W x H --in. (mm) 27.87 x 17.50 x 16.60
(708 x 445 x 422)
31.07 x 18.10 x 17.50
(789 x 460 x 445)
with Sound Shield 31.07 x 18.10 x 17.50
(789 x 460 x 445)
31.07 x 18.10 x 17.50
(789 x 460 x 445)
Weight--(wet), lbs. (kg) 190 (86) 231 (104)
with Sound Shield 213 (96) 231 (104)
Air Requirements--cfm (L/min.) 18 (510) 18 (510)
Fuel Consumption U.S. gal./hr. (L/hr.)
Load
25% 0.48 (1.81) 0.53 (2.00)
50% 0.55 (2.08) 0.62 (2.34)
75% 0.62 (2.34) 0.86 (3.25)
100% 0.68 (2.57) 1.02 (3.86)
- Operation and 1
- Installation Manual 1
- California Proposition 65 2
- Table of Contents 3
- HAZARDOUS VOLTAGE/ 4
- ELECTRICAL SHOCK 4
- EXHAUST SYSTEM 5
- FUEL SYSTEM 7
- ACCIDENTAL STARTING 8
- MOVING PARTS 8
- HOT PARTS 8
- ENGINE BACKFIRE/FLASH FIRE 9
- HAZARDOUS NOISE 9
- Reference Material 11
- Commercial Vessels 12
- Additional References 12
- Routine Service Parts 13
- Glossary of Abbreviations 14
- Section 1. Specifications 16
- Generator 17
- Engine (Continued) 19
- Accessories 20
- Service Views 21
- Section 2. Operation 22
- Controller 23
- Starting 24
- Stopping 24
- Circuit Protection 25
- Engine Safety 25
- Shutdown Switches 25
- High Water Temperature 26
- Shutdown Switch 26
- High Exhaust Temperature 26
- Remote Panels (Optional) 27
- Remote Start and Four-Meter 28
- Panel Kit 28
- Service Schedule 30
- Service Schedule (Continued) 31
- Lubrication System 32
- Adding Oil 33
- Oil Change/Oil Filter Change 33
- Fuel System 34
- Fuel Pump Screen 35
- Carburetor/Choke Lubrication 36
- Carburetor Adjustments 36
- Ignition System 37
- 1. 0.028--0.031 in 39
- (0.7--0.8 mm) Gap 39
- 2. Spark Plug Electrodes 39
- Cooling Systems— 40
- Closed/Heat Exchanger 40
- Flushing and Cleaning 42
- Anticorrosion Zinc 44
- Air Cleaner and 45
- Mixing Elbow 45
- Cleaning 46
- Checking Electrolyte Level 46
- Checking Specific Gravity 46
- Charging 47
- Valve Adjustment 48
- Governor 50
- Wattage Requirements 51
- Generator Service 51
- Storage Procedure 52
- Section 4. Troubleshooting 53
- Electrical System 55
- 246482-D 57
- Electro Switch 59
- (Early Rectangular Design) 59
- (Newer Round Design) 59
- Configuration--Figure 5-4 60
- Figure 5-5 (Single Pole) 60
- 120/240- or 110/220-Volt 61
- Configuration--Figure 5-6 61
- Section 6. Installation 63
- Appliance Loads 64
- Kilowatt Derating 64
- TOTAL HOURS 65
- Fuel Systems 67
- Anti-Siphon Provisions 68
- Fuel Lines 68
- Fuel Consumption 68
- Cooling Systems 69
- Exhaust Systems 71
- Electrical Systems 74
- 1. Battery Positive (+) 75
- Connection 75
- 2. Battery Negative (--) 75
- ADV-5792-D 77
- TP-5695 12/93 81
- PRINTED IN U.S.A 81
Related products and manuals for Power generators Kohler 3.5CFZ
Power generators Kohler 3.5EFOZ User Manual
(44 pages)
(44 pages)
Power generators Kohler 12RESM1 User Manual
(40 pages)
(40 pages)
(40 pages)© 2020, manymanuals.com. All rights reserved. | 0.647 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals