Kohler K-R709062-L-MX Installation Guide download pdf (Page 2)

Rails

Bottom

Track

Bumper

Hanger

Bracket

Gasket

8-32 x 1/4"

Barrel

Nut

Hanger

Bracket

No Gap

at Top

#8-32 x 3/8"

Label

Screw

Roller

Label Side

Rollers

Screw

Label

#8-32 x 3/8"

Label

Side

Center of the

Bottom Track

Guide

Bottom Track

Lower the glass.

Raise the glass.

Bottom Track

Guide

Self-Tapping

Screws

Outside of the

Shower

Door

Panel

Corner Protector

Spacers

Back Plate

9/64"

Post

Warranty

ONE-YEAR LIMITED WARRANTY

KOHLER plumbing products are warranted to be free of defects in material and workmanship for one year from

date of installation.

Kohler Co. will, at its election, repair, replace or make appropriate adjustment where Kohler Co. inspection discloses

any such defects occurring in normal usage within one (1) year after installation. Kohler Co. is not responsible for

removal or installation costs. Use of in-tank toilet cleaners will void the warranty.

To obtain warranty service contact Kohler Co. either through your Dealer, Plumbing Contractor, Home Center or

E-tailer, or by writing Kohler Co., Attn.: Customer Care Center, 444 Highland Drive, Kohler, WI 53044, USA, or

by calling 1-800-4-KOHLER (1-800-456-4537) from within the USA and Canada, and 001-800-456-4537 from within

Mexico, or visit www.kohler.com within the USA, www.ca.kohler.com from within Canada, or www.mx.kohler.

com in Mexico.

IMPLIED WARRANTIES INCLUDING THAT OF MERCHANTABILITY

AND FITNESS FOR A PARTICULAR PURPOSE ARE EXPRESSLY LIMITED IN DURATION

TO THE DURATION OF THIS WARRANTY. KOHLER CO. AND/OR SELLER DISCLAIM

ANY LIABILITY FOR SPECIAL, INCIDENTAL OR CONSEQUENTIAL DAMAGES. Some states/provinces do

not allow limitations on how long an implied warranty lasts, or the exclusion or limitation of special, incidental or

consequential damages, so these limitations and exclusions may not apply to you. This warranty gives you specific

legal rights. You may also have other rights which vary from state/province to state/province.

This is Kohler Co.’s exclusive written warranty..

Troubleshooting

Symptom: Alignment Recommended Action

1. The top of the door panel is tilted away from

the wall.

A. Remove the door panel from the top track and lower the roller that is closest to the wall. See step 21.

2. The bottom of the door panel is tilted away

from the wall.

A. Remove the door panel from the top track and raise the roller that is closest to the wall. See step 21.

3. The door panel does not touch the bumper. A. Determine whether the door panel top or bottom is closer to the wall, and then adjust the roller closest to the wall.

4. The bottom track is miscut or skewed. A. The notched wall jamb fits over the bottom track to cover any miscut or skewed cuts. Seal as directed to ensure

proper watertight seal. See step 25.

Symptom: Water Leaks Recommended Action

1. Water leaks between panels. A. When showering, make sure the inside panel is against the showerhead wall.

2. Water leaks between the wall jamb and the

door panel.

A. Adjust the door panel to line up with the wall jamb. Add the optional seal. See step 24 and 25.

3. Water leaks under the bottom track. A. Check for proper silicone sealant application. See steps 24 and 25. Apply more silicone sealant in the leak location.

Symptom: Operation (open/close) Recommended Action

1. The inside and/or outside panel is difficult to

move.

A. Ensure a gap exists between the guide and the door panel. If no gap exists, lower the rollers.

B. Ensure the inside center guide is properly secured with the self-tapping screws. See step 21.

C. Ensure the rollers are properly installed. See steps 14, through 18.

D. Clean any debris in the top track groove.

E. Ensure that the hanger bracket is tight to the glass.

Position the top track over the wall jambs. Either

side of the top track may face out. At each end of

the top track, insert and twist a bumper 1224786

into place over the rails. Slide the bumpers

against the wall jambs.

Install the bottom bumpers. Bumper 1225277

installs on the right side jamb. Bumper 1225276

installs on the left side jamb. Orient each bumper

with the number against the wall jamb.

For both doors, slide a gasket over the top of the

door panel and into each mounting hole. Press

the hanger bracket over the gasket and align the

hanger brackets with the mounting holes.

While pressing downward on the hanger

brackets, use screwdrivers to thread the bolts

into the barrel nuts. Tighten until the hanger

brackets are secured firmly in place.

On the inside panel, assemble a roller to the

middle hole of each hanger bracket. Install

the rollers on the side of the door panel that is

opposite the label.

Lift the inside panel onto the inside track. The

label faces the outside of the shower.

On the outside panel, assemble a roller to the

middle hole of each hanger bracket. Install the

rollers on the same side of the door panel as the

label.

Tilt the top of the outside panel toward you,

carefully lift the bottom edge over the bottom

track, and position the rollers on the outside rail.

Remove the protective corners from the bottom

of both door panels. Position both doors on the

same side of the opening.

Measure to determine the center of the bottom

track and mark. Position and center the guide on

the bottom track and align the door panels with

the guide.

On the inside of the shower, hold the guide

against the bottom track and slide the doors

from wall to wall. If the doors stick, remove the

door and position the rollers in the lower hole to

raise the glass or upper hole to lower the door.

Hold the guide in place and secure with the two

self-tapping screws. Do not overtighten!

Press a spacer onto each back plate and post.

Use a 9/64” hex wrench to assemble the handles

as shown.

Outside the shower, use silicone sealant to seal

along the entire length of the wall jambs and the

bottom track.

Inside the shower, use silicone sealant to seal

along the entire length of the wall jambs and

where the wall jambs meet the bottom track.

11 12

1 2 3 4

Comments to this Manuals

No comments

Kohler K-R709062-L-MX Installation Guide Page 2

Comments to this Manuals

Related products and manuals for Unknown Kohler K-R709062-L-MX